Garlic Pork Sausage

I have made sausage a couple times before but not this much and not this kind.  O Wow!,  was it a chore. If I ever make them again in this amount, I am going to invest in some sausage making equipment. I used a KitchenAid meat grinder and sausage stuffing tube to make these and it's almost a toy compared to a dedicated grinder/stuffer. It seemed to take forever.The stuffing tube was too small for the bigger diameter sausage and it seemed to take a really long time to do those.  Unlike the original recipe, I am smoking these before cooking.  Here they are after one hour on the smoker @ 225-230º.  In another hour, I'll take them off and cook up some for dinner tonight.  I will probably freeze the rest.  I was going to use a combination of beef brisket trimmings that I had saved from the last 3 or 4 briskets I smoked plus the pork trimmings from the ribs I did the other day but when I went to the freezer to get the brisket trimmings, they were gone.  I noticed the freezer was half full with tamale stuff so I wonder who threw out the brisket?  Hmm.  Anyway I pan sauteed a little bit to see how the seasonings were and it was really good. 

Garlic Pork Sausage           Recipe courtesy of Anne Burrell

Total Time 1 hr 15 min   Prep:55 min   Cook:20 min    Yield:18 to 20 sausages   Level:Advanced

Ingredients

5 pounds pork shoulder, a good mix of lean and fat, cut into 1-inch chunks

12 cloves garlic, smashed

1 large bunch fresh sage or 2 small ones, finely chopped

1/4 cup salt

2 tablespoons crushed red pepper

3/4 cup cold water

1 cup grated Parmesan

Hog casings, rinsed with water run through them and stored in fresh water

Special equipment: meat grinder and sausage stuffer

Directions

In a large bowl, combine the pork, garlic, sage, salt and crushed red pepper. Run the meat mixture through the meat grinder outfitted with the die with the largest holes. Repeat so that all of the meat goes through the grinder twice.

Place half of the meat mixture in the bowl of a standing mixer equipped with the paddle attachment. Add half of the water and half of the Parmesan and beat on medium-high for 3 to 4 minutes. Repeat this process with the remaining meat, water and cheese.

Make, cook and eat a test patty to make sure the sausage is delicious.

Attach the sausage-stuffing attachment to the meat grinder, keeping the grinder blade and die in place also.

Keeping the sausage casing very wet, slide a manageable length onto the sausage stuffer. Place a generous amount of the prepared sausage mixture into the grinder pan. Give the casings a slight bit of resistance by holding onto the sausage stuffer with your three last fingers and letting the casing slip through your thumb and forefinger. Turn the machine on a medium-low speed and fill the casings, being careful to avoid any air bubbles. To get the feel for stuffing the sausages, you might have to do a couple tries. The first couple might be too loose or too tight; that's ok--think of them as the first pancake (the one that never comes out right that you have to throw away).

Twist the casings to create sausages that are even in size. Tie each with butcher's twine to keep them nicely sealed. Prick the sausages with a pin or skewer all over to allow steam to escape while cooking (you don't want to have a blowout).

Preheat a grill or saute pan. Cook the sausages until cooked through, 7 to 8 minutes on each side. Serve immediately or at room temperature.

Cook's Notes: This is a BIG batch of sausage, but it freezes really well.

If you have casings left over, pack them in salt and store them in your fridge--they will last a REALLY long time.